Samsung RSG257AA Bedienungsanleitung PDF herunterladen

Fast Track Troubleshooting

IMPORTANT SAFETY NOTICE – “For Technicians Only” This service data sheet is

intended for use by persons having electrical, electronic, and mechanical experience

and knowledge at a level generally considered acceptable in the appliance repair trade.

Any attempt to repair a major appliance may result in personal injury and property

damage. The manufacturer or seller cannot be responsible, nor assume any liability for

injury or damage of any kind arising from the use of this data sheet.

Models Covered:

RSG257AABP/XAA,

RSG257AAPN/XAA,

RSG257AARS/XAA,

RSG257AAWP/XAA

French Door Refrigeration

Press Freezer button a

third time to Force Low

Speed Run

Wait 5 seconds between button pushes

Press Freezer button a

forth time to Force De-

frost of Fridge & Freezer,

measure defrost voltage

at main PCB

Press Freezer button one

time at the Test Mode to

Force Compressor High

Speed Run, measure fan

and Compressor volt-

ages at main PCB

Self Diagnosis: Press both buttons (Power

Freeze– Lighting) simultaneously (No sound

when both buttons are pressed at the same

time) ’til the display quits blinking and

beeps, 8-12 seconds, then release and read

Fault Codes. This will also cancel the Fault

Mode created by self-diagnosis at power up.

Forced Mode: Press both buttons (Power

Freeze– Fridge) simultaneously (No sound

when both buttons are pressed at the same

time) ‘til it beeps and goes blank, 8-12 seconds

Publication # tsRS257AA Revision Date 08/12/2010

Sealed System

Component Value Chart

Sales Mode, No Compressor Operation

Press Power Freeze & Freezer temp buttons

simultaneously for 3 sec ( you will hear a “Ding

Dong”) to remove or put into Sales Mode. When in

the Sales Mode the Display will show "OF" "OF"

Removing power will not cancel this mode.

Press Freezer button a

second time to Force

Mid Speed Run

3600RPM 2450RPM 2200RPM

Refrigerant Charge

R134a 7.1 oz.

1. Compressor  Sub-condenser  Hot Pipe  Back Clus-

ter Pipe  Dryer  R Capillary Tube  Refrigerator Evapo-

rator  Connected Capillary  Freezer Evaporator  Suc-

tion Pipe  Compressor

2. Compressor  Sub-condenser  Hot Pipe  Back Clus-

ter Pipe  Dryer F Capillary Tube  Freezer Evaporator

 Suction Pipe  Compressor

Component Resistance Wattage Voltage

Freezer Defrost Heater 58 250 120vac

Fridge Defrost Heater 103 140 120vac

Fill Tube Heater 2645 4.6 120vac

Dispenser Heater 1763 7 120vac

Water Tank Heater 3600 4 120vac

Sensors 2.5k-89k N/A 1~4.5vdc

Fans N/A N/A 7~12vdc

NOTICE: 02/10

RSG257AA** Parts

Change: Refer to bulletin.

Door Ass’y Connectors, Ice

Maker, & Auger Ass’y

NOTICE: 06/10

RSG257AA** Parts

Change: Refer to bulletin.

Both Evaps, Def Heaters,

Evap covers, & Water

Tank

1 2 3 4 5 6 7

Inhaltsverzeichnis

Seite 1 - Fast Track Troubleshooting

Fast Track Troubleshooting IMPORTANT SAFETY NOTICE – “For Technicians Only” This service data sheet is intended for use by persons having electrical,

Seite 2

Temperature/Resistance/Voltage Chart for Samsung Refrigerators Sensors Heat Release I/M Test Mode

Seite 3

Error Items LED TROUBLE TESTINGI/M-SENSOR (R on Twin I/M units ) Ice Maker Sensor Error- open or short-circuit, connector failure. Cause is also a tem

Seite 4

CN02 Overload & A/C Line1 OLP (Brn)3 OLP (S/Blu)3 L (Red)1 N (Gry)CN04 Compressor Control1-(CN75-10) +13vdc (Blk-Gry) 2-(CN75-10) 5vdc (Brn-Gry)4

Seite 5 - RSG257 Main PCB

CN402-1 Ambient Sensor (Yel-Yel) 1.2~2 vdc3-4 Freezer door Sw (Wht/Grn-Gry)5-4 F Sensor (Yel-Gry) 3.5~4.2vdc6-4 F-Def Sensor (Blu-Gry) 2.3~4.2vdc7-8 R

Seite 6 - WIRING DIAGRAM

126WIRING DIAGRAM7-3) RSG257* Defrost Heater Resistance Information Reversed 6

Seite 7 - RSG ice maker in door

RSG ice maker in doorIce Maker Cover: Pull out on bottom of cover and lift upIce bucket ass’y is removed by pulling the locks on both sides of the bin